Product ID:520 ADHESIVE
MSDS Date:03/19/1993
FSC:8040
NIIN:00-550-8835
Status Code:A
MSDS Number: CLNWW

ARMSTRONG WORLD INDUSTRIES, INC.

313 W. LIBERTY ST.
LANCASTER, PA 17604
US

Emergency Phone: 800-424-9300

Info Phone: 717-396-2328; 717-396-2935

Preparer: ERNEST CARTER

Cage: 03938

ARMSTRONG WORLD INDUSTRIES, INC.

3209 LANCASTER, PA 17604 US

Telephone: 717-396-2328; 717-396-2935

Cage: 03938

ACETONE

CAS: 67-64-1

RTECS: AL3150000

OSHA PEL 2400 MG/M3;1000 PPM

ACGIH TLV: 1780 MG/M3;750 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

TOLUENE

CAS: 108-88-3

RTECS: XS5250000

OSHA PEL see Table Z-2

ACGIH TLV: 188 MG/M3;50 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

HEXANE

CAS: 110-54-3

RTECS: MN9275000

OSHA PEL 1800 MG/M3;500 PPM

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

SYNTHETIC RUBBER

CAS: 9010-98-4

RTECS: EI9640000

PHENOLIC RESIN

RUBBER CURING INGREDIENTS

Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Effects of Overexposure:SKIN AND EYES: EXCESSIVE SKIN CONTACT MAY CAUSE
DRYING AND CRACKING OF THE SKIN, AND RESULT IN DERMATITIS. CONTACT
WITH EYES WILL CAUSE IRRITATION. INHALATION: IRRITATION OF
RESPIRATORY TRACT, COUGHI NG, HEADACHE, DIZZINESS, DROWSINESS,
NAUSEA, UNCOORDINATED MOVEMENTS.
Medical Cond Aggravated by Exposure:ANY CONDITION GENERALLY AGGRAVATED
BY SOLVENTS; PREEXISTING UPPER RESPIRATORY AND LUNG DISEASES SUCH
AS, BUT NOT LIMITED TO BRONCHITIS, EMPHYSEMA, AND ASTHMA.

First Aid:SKIN AND EYES: FLUSH ANY SKIN OR EYE CONTACT WITH PLENTY OF
WATER. SKIN CONTACT, WASH WITH SOAP AND WATER.REFER TO PHYSICIAN IF
IRRITATION OR SYMPTOMS PERSIST. INHALATION: REMOVE TO FRESH AIR IF
EXPOS ED TO EXCESS CONCENTRATIONS OF VAPOR. SEEK MEDICAL ATTENTION
IF SYMPTOMS PERSIST.

Flash Point Method:PMCC
Flash Point:=-6.5C, 20.F
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, HALON.
Fire Fighting Procedures:PROTECT FIRE FIGHTERS FROM TOXIC PRODUCTS OF
COMBUSTION BY WEARING SELF-CONTAINED BREATHINF APPARATUS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS IN A FIRE MAY RUPTURE
DUE TP PRESSURE BUILDUP.

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AREA
OF SPILL OR LEAK; IF USING MECHANICAL VENTILATION, MAKE SURE THAT
IT IS EXPLOSION PROOF OR DOES NOT PRESENT AN IGNITION SOURCE. FOR
EXPOSURE ABOVE TLV, W EAR APPROVED RESPIRATORY EQUIPMENT. CONTAIN
SPILL, PREVENTING IT FROM ENTERING SEWER LINES OR WATERWAYS.USE
ABSORBENT TO ASSIST WITH THE PICK-UP OF MATERIAL. SCRAPE UP
ADHESIVE AND PLACE IN CONTAINER.

Handling and Storage Precautions:RECOMMENDED STORAGE TEMPERATURE IS
BELOW 90 DEGREES F.
Other Precautions:VAPORS ARE FLAMMABLE AND ARE
HEAVIER-THAN-AIR.PROHIBIT SMOKING AND ELIMINATE ALL OTHER SOURCES
OF IGNITION,SUCH AS REGULAR ELECTRICAL TOOLS AND APPLIANCES, MAKING
SURE THAT PILOTS ON GAS-FIRED WATER H EATERS ARE EXTINGUISHED.
WARNING: THIS PRODUCT CONTAINS TOLUENE, A CHEMICAL KNOWN TO THE
STATE OF CA LIFORNIA TO CAUSE BI

Respiratory Protection:WITH ADEQUATE VENTILATION, RESPIRATORY EQUIPMENT
SHOULD NOT BE NEEDED. IF ADEQUATE VENTILATION IS NOT AFFORDED,WEAR
RESPIRATORY EQUIPMENT APPROVED FOR ORGANIC VAPORS.
Ventilation:THE VENTILATION SHOULD BE SUFFICIENT TO KEEP THE SOLVENT
VAPOR CONCENTRATION BELOW THE TLV.
Protective Gloves:IMPERVIOUS GLOVES (COTTON OR LOOP PILE)
Eye Protection:SAFETY GLASSES ARE RECOMMENDED.
Supplemental Safety and Health

Boiling Pt:>66.7C, 152.F
Spec Gravity:0.83
Solubility in Water:NEGLIGIBLE
Appearance and Odor:STRAW COLORED LIQUID WITH CHARACTERISTIC SOLVENT
ODOR

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE, AND
OTHER TOXIC VAPORS AND GASES THAT ARE COMMON TO THERMAL DEGRDATION
OF ORGANIC COMPOUNDS.
Conditions to Avoid Polymerization:WILL NOT OCCUR.

Waste Disposal Methods:INCINERATION OR OTHER METHOD APPROVED FOR
IGNITIBLE WASTES IN ACCORDANCE WITH FEDERAL, STATE, AND LOCAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.